OMC Marine 800 series lower unit repair cost

Outdrive repair services required by customers prices include labor, seal kit, 680 retaining compound, aviation gasket sealant and 545 thread sealant
Machine seal area of bearing retainers, spray paint OMC outdrive case with zinc chromate primer and white apoxy or silver enamel paint
Vacuum / pressure test omc 800 lower unit

Click here for new 800 series lower unit gearcases

# 224-27 800 Series basic lower unit repair cost

# 224-27 Basic 400/800 1982 thru 1986 lower unit basic parts and flat rate repair cost $495.00

*Please remove exhaust housing from lower unit before shipping. An additional $140 charge will be applied for units shipped with exhaust housing attached*

# 224-28 Basic 400/800 servo hydraulic shift assist 1978 thru 1980 lower unit basic parts and flat rate repair cost $760.00

Dial indicate shaft

Take apart clean, wire brush, sand, zinc chromate primer inside bearing carrier hub, change drive shaft bearing, primer and paint outside area with

Install new seal kit

Pressure test unit

Repair parts and pricing listed on web page under 800 series lower gearcase

87630 Lower unit seal kit $45.79 (included)

11190 Drive shaft nut $9.79 (included)

68015 Loctite retainer compound $32.79 (included)

30517 Aviation gasket sealant $12.79

21610 Bearing $31.79 (included)

11410 Bearing carrier bearing $9.79 (included)

35605 Zinc chromate primer (included)

36979 Silver factory matched to OEM (included)

78819 White epoxy enamel base 24hr. cure time (included)

OMC stern drive parts cost that may be required for the repair

# 87630 OMC 800 lower unit seal kit $45.79

# 22730 Bearing housing $96.79

# 22666 Heavy duty gears 14/26 $424.79

# 22414 Propeller shaft $306.79

# 22413 Drive shaft $289.79

# 11406 Bearing carrier V6 or V8 $197.79

# 21610 Bearings $31.79

# Welding housing welding $160.00

# 22625 Clutch dog $95.79

Shift cable cut rubber leak repair $106.00

There is a 55.00 to 85.00 fee for packaging and shipping to USA / Canada

Ship To

T.C.Electronics / Marine

21 Canadian road unit 17

Toronto Ontario

Canada M1R 5G2

OMC Cobra Lower Gear Cases

Place in 26" x 32" x 10" Box 48 to 56 lbs

Pack with solid foam from building centre. Unit can or may be disassembled or one piece.

Please make sure there is No Oil in Unit.

Please Ship UPS 4 to 6 day ground service.

Pricing $ 30.00 to $ 68.00 cost in Continental USA.

Two Day Delivery is available in most areas. Call for rates UPS 1 (800) 742-5877

***NOTE if sending core***

Please State on UPS Form

Value for customs $10.00 Boat Parts for Repair Only or( Brokerage/Customs Charges) and Taxes Will Be Charged . Sender Will be Responsible for these charges.